VALE/SUPERIOR SKID MOUNTED 6X20 WASH PLANT AS DESCRIBED BELOW: SUPERIOR GUARDIAN 6203HBS TRIPLE SHAFT HORIZONTAL SCREEN - 0 DEGREE INCLINE - RIGHT HAND DRIVE - 55 DEGREE TIMING AND ZERO PLUG WEIGHTS INSTALLED - COIL SPRINGS WITH MHSA GUARDS - ALL DECKS SIDE TENSIONED WITH 5FT CLAMP BAR CONFIGURATION - VALE SUPPLIED BASEFRAME STRUCTURE - STRUCTURAL ENGINEERED SUPPORT FOR ONE 6X20 SCREEN - WELDMENT AND BOLT TOGETHER DESIGN - INCLUDING ALL FASTENERS FOR FIELD ERECTION PLAFROM HANDRAIL LADDER - SCOPE INCLUDES 2›¼À™ WIDE PLATFORM ON 2 SIDES AND AT BACK OF SCREEN - LOCAL PLATFORM OVER SCREEN DRIVE MOTOR STANDARD DESIGN - CHECKER PLATE PLATFORM WITH 6›¼À KICK PLATES - 42›¼ÀHSS 1.5›¼À HANDRAIL WITH MID-RAIL AND POSTS REMOVABLE - SAFETY GATE SELF-CLOSING UP TO 30›¼À WIDE ACCESS POINTS STAIRCASE ACCESS - APPROXIMATELY 16 RISER STAIRCASE - DIAMOND GRIP STAIR TREADS 9.5 X 30›¼À - C6 CHANNEL -HSS 1.5 HANDRAIL WITH MID-RAIL AND POSTS SCREEN FEED PUMP BOX - ENGINEERED STRUCTURAL SUPPORT FOR ONE SLURRY BOX 6›¼À™X6›¼À™X4›¼À™ - MOUNT PUMP BOX DIRECTLY OVER SCREEN FEED BOX - 10›¼À FLANGE TO CONNECT PIPING - PIPE ELBOWS AND FITTINGS FROM GRADE TO PUMP BOX BY END USER - 1/2" URETHANELINERS PLUG WELD SCREEN DISCHARGE FRAME AND CHUTES - ROLLOUT FRAME - MANUAL ROLL AND PIN SYSTEM - TOP DISCHARGE CHUTE SLOPED 3/8›¼À PLATE DESIGN 1/4›¼À AR 400LINER WELD IN - MIDDLE AND BOTTOM DECK CHUTES WITH ROCK SHELF 1/4›¼À PLATE 1/2›¼À URETHANE STEEL BACKED PLUG WELD UNDER SCREEN FLUME - 1/4›¼À PLATE HOPPER WITH SLOPED SIDEWALLS - 1/2" URETHANE LINER PLUG WELD DISCHARGE TO SUMP: - SUMP SUPPLIED BY OTHERS - PIPING FROM SUMP TO SCREEN FEED PUMP BOX BY OTHERS WASH MANIFOLD/SPRAY BARS - FULL LENGTH 6›¼À X 6›¼Àœ MANIFOLD WITH 6›¼À BOLT FLANGE FOR WATER HOOKUP - INDIVIDUAL GATE VALVES FOR ADJUSTABLEWATER FLOW - 4 FLUSH VALVES TO UNDER SCREEN FLUME LOCATED AT FEED AND DISCHARGE - 16 BAR WASH KIT INCLUDING BOOTS SPRAY BARS AND BRASS NOZZLES FOR SCREEN SUPPLIED BY VALE - 6›¼À FRESH WATER FEED PIPE ELBOWS AND FITTINGS FROM GRADE TO MANIFOLD BY OTHERS OWNER›¼À™S MANUAL AND PARTS LIST ELECTRICAL SWITCHGEAR AND POWER CORD NOT INCLUDED AT THIS TIME CONCRETE FOUNDATION RECOMMENDED TO SUPPORT STRUCTURE AND VIBRATORY EQUIPMENT WARRANTY COULD BE DENIEDIF FOOTING ALLOWS MOVEMENT AND SUBSEQUENT VIBRATION AND FALIURE OF FOUNDATION. CRANE INSTALLATION AND ASSEMBLY ONSITE NOT INCLUDED AT THIS TIME. GUARDING - WE DO NOT WARRANT THAT MANUFACTURERS›¼À™ GUARDING WILL MEET ALL LOCAL CODES.IT IS THE RESPONSIBILITY OF THE END USER TO HAVE GUARDING CHECKED BY A LOCAL INSPECTOR PRIOR TO STARTUP OF EQUIPMENT OPERATIONS CORRECTIVE ACTIONS AND ASSOCIATED EXPENSE ARE THE RESPONSIBILITY OF THE END USER.